ricoh mp 2851

[Transam1]

I have a Ricoh mp 2851 with the optional 2 tray paperbank
have replaced the pick up roller and clutch still occassionally
says paper jam open side door and remove jam
when you open door there is no jam it hasn t even picked up
paper. close the door and off it goes any ideas ?

[TechnicianWilson]

Re: ricoh mp 2851

clean & check photo eyes for paper dust

[slimslob]

Re: ricoh mp 2851

Check operation of paper lift. If the paper lift sensor gets activated too soon, as paper is fed, the level of the top sheet can get to the point where the pick up roller is not in contact before the lift sensor has activated to turn the lift motor back on. I have seen this caused by warped lift pan and by there being 5 or more sheets of paper with corners bent under there by lifting the back corner of the paper, where the lift sensor is, higher than the center of the paper where the feed is.

[Transam1]

Re: ricoh mp 2851

Check operation of paper lift. If the paper lift sensor gets activated too soon, as paper is fed, the level of the top sheet can get to the point where the pick up roller is not in contact before the lift sensor has activated to turn the lift motor back on. I have seen this caused by warped lift pan and by there being 5 or more sheets of paper with corners bent under there by lifting the back corner of the paper, where the lift sensor is, higher than the center of the paper where the feed is.

Thanks I will have a look